Sintesis Magnesium Ferit Berbasis Pasir Besi dari Sarmi menggunakan Metode Kopresipitasi

Cahyo Saputra; Heru Cahyoutomo; Jeny Sendong; Octolia Togibasa

doi:10.20527/flux.v17i2.6932

Sintesis Magnesium Ferit Berbasis Pasir Besi dari Sarmi menggunakan Metode Kopresipitasi

Cahyo Saputra, Heru Cahyoutomo, Jeny Sendong, Octolia Togibasa

Abstract

In this study, magnesium ferrite was sinthesized from natural iron sand using co-precipitation method. Iron sand material was taken from the north coast of Sarmi Regency, Papua Province. The purpose of this study was to find out whether magnesium ferrite could be synthesized from iron sand directly without preliminary processes into magnetite minerals. Co-precipitation method was applied with a variant of stirring temperature of 30, 50 and 70°C. The crystal structures was characterized using an x-ray diffractometer, while the magnetic properties was characterized using a vibrating sample magnetometer and the morphology of the particle was characterized using a scanning electron microscpe. From the results of characterization, it is known that magnesium ferrite successfully synthesized from iron sand directly without preliminary processes into magnetite minerals. Magnetic properties were obtained from the sample with added of magnesium acetate tetrahedral and stirred at a temperature of 70°C. The x-ray diffracttion pattern showed figure of merit of 0.82, while the magnetic hysterisis curve shows coercivity of 200 Oe and magnetic moment about 11 emu/gr. The mineral has irregular particle sizes that range from 0.5 to 100 microns in size, due to magnetic attraction which promotes agglomeration. This researcher recommends optimization of the synthesis process so that the quality of the magnesium ferrite can be improve.

Keywords

Iron Sand, Iron Oxide, Co-precipitation Method and Magnesium Ferrite

Full Text:

PDF (Bahasa Indonesia)

References

Bader, N., Benkhayal, A.A. & Zimmerman, B. (2014). Co-presipitation as a Sample Preparation Technique For Trace Element Analysis: an Overview. Int. J. Chem. Sci: 12(2), 519-525

Chen, Q., Rondinone, A.J., Chakoumakos B.C. & Zhang Z.J. (1999). Synthesis of Superparamagnetic MgFe2O4 Nanoparticles by Coprecipitation. Journal of Magnetism and Magnetic Materials 194, 1 - 7.

Hankare, P.P., Jadhav, S.D., Sankpal, U.B., Patil, R.P., Sasikala R. & Mulla, I.S. (2009). Gas Sensing Properties of Magnesium Ferrite Prepared by Co-precipitation Method. Journal of Alloys and Compounds 488 (1), 270–272.

Jayanti, D.N. (2014). Optimalisasi Parameter pH Pada Sintesis Nanosilika dari Pasir Besi Merapi dengan Ekstraksi Magnet Permanen Menggunakan Metode Kopresipitasi. Skripsi. Yogyakarta

Liang, X., Wang, X., Zhuang, J., Chen, Y., Wang, D. & Li Y. (2006). Synthesis of Nearly Monodisperse Iron Oxide and Oxyhydroxide Nanocrystals. Journal of Advance Functional Materials. 16: 1805-1813

Liu, C.P., Li, M.W., Cui, Z., Huang, J., Tian, Y., Lin, T. & Mi, W. (2007). Comparative Study of Magnesium Ferrite Nanocrystallites Prepared by Sol–Gel and Coprecipitation Methods. Journal of Materials Science 42 (15), 6133 - 6138.

Mufti, N., Atma, T., Fuad, A. & Sutadji, E. (2014). Synthesis and Characterization of Black, Red and Yellow Nanoparticles Pigments From The Iron Sand. AIP Conference Proceedings 1617 (1), 165-169.

Patil, J.Y, Khandekar, M.S, Mulia, I.S & Suryavanshi S.S. (2012). Combustion Synthesis of Magnesium Ferrite as Liquid Petroleum Gas (LPG) Sensor: Effect of Sintering Temperature. Current Applied Physics 12 (1), 319-324.

Pradeep, A., Priyadharsini, P. & Chandrasekaran G. (2008). Sol-Gel Route of Synthesis of Nanoparticles of Magnesium Ferrite and XRD, FTIR and VSM Study. Journal of Magnetism and Magnetic Materials 320 (21), 2774-2779.

Putz, H. (2003). Tutorial Hanbook. MATCH! Phase Identification From Powder Diffaction-Version 2. Bonn, Germany: Crystal Impact

Rajjab, A., Mahmood, A., khan M.A., Chughtai, A.H, Shahid, M, Shakir, I. & Warsi, M.F. (2014). Impacts of Ni–Co Substitution on The Structural, Magnetic and Dielectric Properties of Magnesium Nano-Ferrites Fabricated By Micro-Emulsion Method. Journal of Alloys and Compounds 584, 363–368.

Setiadi E.A, Sebayang, P, Ginting M, Sari, A.Y., Kurniawan, C, Saragih, C.S. & Simamora P. (2016). The Synthesization of Fe3O4 Magnetic Nano Partikels Based on Natural Iron Sand by Co-presiptation Method for the Used of the Adsoption of Cu and Pb

Ions. Journal of Physics: Conference Series 776(1), 012020.

Setiadi, E.A., Yunus, M., Nanaban, N., Simbolon, S., Kurniawan C., Humaidi S., Sebayang, P. & Ginting M. (2018). The Effect of Temperature on Synthesis of MgFe2O4 Based on Natural Iron Sand by Co-Prespitation Method as Absorbent Pb Ion. Journal of Physics : Conference Series 985 (1), 012046

Shen, Y., Wu, Y., Li, X., Zhao, Q. & Hou, Y. (2013). One-pot Synthesis of MgFe2O4 Nanospheres by Solvothermal Method. Materials Letters 96 , 85–88.

Subagja, B. (2011). Pengaruh Variasi Persen Berat Bi dan Pemberian Tekanan Pada Parametr Kisi dan UKuran Kristal Sistem Material Sn-Cu-Bi dan Sn-Cu. Skripsi. Universitas Indonesia. Depok.

Togibasa, O., Bijaksana, S. & Novala, G.C. (2018). Magnetic Properties of Iron Sand from the Tor River Estuary, Sarmi, Papua. Geosciences. 8(4), 113

Togibasa, O., Akbar, M., Pratama, A. & Bijaksana, S. (2019). Distribution of Magnetic Susceptibility of Natural Iron Sand in the Sarmi Coast Area. Journal of Physics: Conference Series 1204, 012074

Verma, S., Joy, P.A., Khollam, Y.B., Potdar, H.S. & Deshpande, S.B. (2004). Synthesis of Nanosized MgFe2O4 Powders by Microwave Hydrothermal Method. Materials Letters 58 (6), 1092 - 1095.

Yulianto, A., Bijaksana S. & Loeksmanto, W. (2003). Comparative Study on Magnetic Characterization of Iron Sand from Several Location in Central Java. Indonesia Journal of Physics, Vol.14 No 2, 63–168.

DOI: http://dx.doi.org/10.20527/flux.v17i2.6932