PENYISIHAN WARNA PADA LIMBAH CAIR INDUSTRI SASIRANGAN DENGAN ADSORPSI KARBON AKTIF

Andy Mizwar; Nurin Nisa Farah Diena

doi:10.20527/infotek.v13i1.1811

PENYISIHAN WARNA PADA LIMBAH CAIR INDUSTRI SASIRANGAN DENGAN ADSORPSI KARBON AKTIF

Andy Mizwar, Nurin Nisa Farah Diena

Abstract

Dye removal from sasirangan textile wastewater by using commercially available activated carbon in a batch reactor was studied. This research explores the effect of activated carbon dosing and contact time on the condition of constant pH and stirring speed toward the effectiveness of dye removal. The results showed that the effectiveness of dye removal of 20.75% - 39.16% with the optimum contact time of 60 minutes and the pattern of dye adsorption by activated carbon in this study were more likely to follow the model of Langmuir Isotherms with a maximum adsorption capacity of 29.412 mg/g.

Keywords

adsorption, activated carbon, sasirangan, dye

Full Text:

PDF

References

Ahmad, A. A., and Hameed, B. H. 2009. Reduction of COD and Color of Dyeing Effluent From a Cotton Textile Mill by Adsorption Onto Bamboo-based Activated Carbon. Journal of Hazardous Materials. Vol 172. No 2-3. 1538-1543.

Allen, S. J. and B. Koumanova. 2005. Decolourisation of Water/Wastewater Using Adsorption.Journal of the University of Chemical Technology and Metallurgy. Vol 40. No 3. 175-192.

Allen, S. J., Mckay, G., and Porter, J. F. 2004. Adsorption Isotherm Models for Basic Dye Adsorption by Peat in Single and Binary Component Systems. Journal of Colloid and Interface Science.Vol 280. No 2. 322–333.

Alvares, A. B. C, Diaper, C., and Parsons, S. A. 2001. Partial Oxidation of Hydrolysed and Unhydrolysed Textile Azo Dyes by Ozone and The Effect on Biodegradability. Process Safety and Environmental Protection. Vol 79. No 2. 103-108.

Babu, B. R., Parande, A. K., Raghu, S., and Prem Kumar, T. 2007. Cotton Textile Processing: Waste Generationand Effluent Treatment. Journal of Cotton Science. Vol 11. 141–153.

Banerjee, P., Dasgupta, S., and De, S. 2007. Removal of Dye from Aqueous Solution Using a Combination of Advanced Oxidation Process and Nanofiltration. Journal of Hazardous Materials. Vol 140.No 1-2. 95-103.

Butt, M. T., Arif, F., Shafique, T., and Imtiaz, N. 2005. Spectrophotometric Estimation of Colour in Textile Dyeing Wastewater. Journal of the Chemical Society of Pakistan. Vol 27. No 6. 627-630.

Erdem, E., Çölgeçen, G., and Donat, R. 2005. The Removal of Textile Dyes by Diatomite Earth. Journal of Colloid and Interface Science. Vol. 282. No. 2. 314–319.

Fan, L., Zhou, Y., Yang, W., Chen, G., and Yang, F. 2008. Electrochemical Degradation of Aqueous Solution ofAmaranth Azo Dye on ACF Under Potentiostatic Model. Dyes Pigments, Vol 76.No 2. 440–446.

Fathima, N. N., Aravindhan, R., Rao, J. R., and Nair, B. U. 2008. Dye House Wastewater Treatment Through Advanced Oxidation Process Using Cu-exchanged Y zeolite: A Heterogeneous Catalytic Approach. Chemosphere.Vol 70. No 6. 1146–1151.

Garcia-Montano, J., Perez-Estrada, L., Oller, I., Maldonado, M. I., Torrades, F., and Peral, J. 2008. Scale Reactive Dyes Degradation by Solar Photo-Fenton and Viological Processes. Journal of PhotochemistryPhotobiology A: Chemistry. Vol 195. No 2-3. 205–214.

Hameed, B. H. 2009. Spent tea leaves: A New Non-conventional and Low-cost Adsorbent for Removal of Basic Dye from Aqueous Solutions. Journal of Hazardous Materials. Vol 161. No 2-3. 753–759.

Hardini, R., Risnawati, I., Fauzi, A., dan Noer Komari. 2009. Pemanfaatan Rumput Alang-Alang (Imperata cylindrica) sebagai Biosorben Cr (IV) pada Limbah Industri Sasirangan dengan Metode Teh Celup. Jurnal Sain dan Terapan Kimia. Vol 3. No 1. 57-72.

Isa M.H., Siew L.L., Asaari F.A.H, Aziz H.A., Azam Ramli N. and Dhas J.P.A. 2007. Low Cost Removal of Disperse Dyes From Aqueous Solution Using Palm Ash. Dyes and Pigments. Vol 74. No 2. 446-453.

Kalderis, D., Koutoulakis, D., Paraskeva, P., Diamadopoulos, E., Otal, E., del Valle, J. O., and Fernández-Pereira, C. 2008. Adsorption of Polluting Substances on Activated Carbons Prepared From Rice Husk and Sugarcane Bagasse. Chemical Engineering Journal. Vol 144. No 1. 42-50.

Khan and Chaudhuri. 2010. Adsorptive Removal of Disperse Red 343 from Aqueous Solution by Coconut Coir Activated Carbon. The 1st IWA Malaysia Young Water Professionals Conference (IWAYP2010). Kuala Lumpur, March 2010.

Lodha, B., and Chaudhari, S. 2007. Optimization of Fenton-biological Treatment Scheme for The Treatment of Aqueous Dye Solutions. Journal of Hazardous Materials. Vol 148. No 1-2. 459-466.

Mahmoud, A. S., Brooks, M. S., and Ghaly, A. E. 2007. Decolorization of Remazol Brilliant Blue Dye Effluent by Advanced Photo Oxidation Process (H2O2/UV system). American Journal of Applied Sciences. Vol 4. No 12, 1054-1062.

Marsh, H. 1989. Introduction to Carbon Science. Butterworths. ISBN 978-0-408-03837-9. UK.

Pinheiro, H. M., Touraud, E., and Thomas, O. 2004. Aromatic Amines from Azo Dye Reduction: Status Review With Emphasis on Direct UV Spectrophotometric Detection in Textile Industry Wastewaters. Dyes and Pigments, Vol. 61. No 2. 121–139.

Putra, M.R.A. 2011.Analisis Peranan Industri Kain Sasirangan Terhadap Perekonomian Kota Banjarmasin dan Strategi Pengembangannya.Tesis.Departemen Ilmu Ekonomi Institut Pertanian Bogor. Bogor.

Syafalni, S., Abustan, I., Dahlan, I., Wah, C.K., and Umar, G. 2012. Treatment of Dye Wastewater Using Granular Activated Carbon and Zeolite Filter. Modern Applied Science. Vol 6. No 2. 37-51.

Wu, J. S., Liu, C. H., Chu, K. H., and Suen, S. Y. 2008. Removal of Cationic Dye Methyl Violet 2B from Water by Cation Exchange Membranes. Journal of Membrane Science. Vol 309. No 1-2.239-245

DOI: http://dx.doi.org/10.20527/infotek.v13i1.1811

DOI (PDF): http://dx.doi.org/10.20527/infotek.v13i1.1811.g1583